PT12-21C中文资料
元器件交易网https://www.wendangku.net/doc/146512844.html,
Technical Data Sheet Chip Phototransistor With Right Angle Lens
PT12-21C/TR8
Features
?Fast response time ?High photo sensitivity ?Small junction capacitance ?Package in 8mm tape on 7” diameter reels. ?Pb free ?The product itself will remain within RoHS compliant version.
Descriptions
?PT12-21C/TR8 is a phototransistor in miniature SMD package which is molded in a water clear with right angle lens. The device is Spectrally matched to visible and infrared emitting diode.
Applications
?Miniature switch ?Counters and sorter ?Position sensor ?Infrared applied system
Device Selection Guide LED Part No.
PT
Chip Material
Silicon
Lens Color
Water clear
Everlight Electronics Co., Ltd. Device No：DTT-012-083
http:\\https://www.wendangku.net/doc/146512844.html, Prepared date：07-20-2005
Rev 2
Page: 1 of 10
Prepared by：David Huang
元器件交易网https://www.wendangku.net/doc/146512844.html,
PT12-21C/TR8
Package Dimensions
Collector Emitter
Notes: 1.All dimensions are in millimeters 2.Tolerances unless dimensions ±0.1mm
Absolute Maximum Ratings (Ta=25℃)
Parameter Collector-Emitter Voltage Emitter-Collector-Voltage Collector Current Operating Temperature Storage Temperature Soldering Temperature *1 Power Dissipation at(or below) 25℃Free Air Temperature Symbol VCEO VECO IC Topr Tstg Tsol Pc Rating 30 5 50 -25 ~ +85 -40 ~ +85 260 75 Units V V mA ℃ ℃ ℃ mW
Notes: *1:Soldering time≦5 seconds.
Everlight Electronics Co., Ltd. Device No：DTT-012-083
http:\\https://www.wendangku.net/doc/146512844.html, Prepared date：07-20-2005
Rev 2
Page: 2 of 10
Prepared by：David Huang
元器件交易网https://www.wendangku.net/doc/146512844.html,
PT12-21C/TR8
Electro-Optical Characteristics (Ta=25℃)
Parameter Rang Of Spectral Bandwidth Wavelength Of Peak Sensitivity Collector-Emitter Breakdown Voltage Emitter-Collector Breakdown Voltage Collector-Emitter Saturation Voltage Collector Dark Current Symbol λ0.5 λP BVCEO BVECO VCE(sat) ICEO Condition ----IC=100μA Ee=0mW/cm2 IE=100μA Ee=0mW/cm2 IC=2mA Ee=1m W/cm2 VCE=20V Ee=0mW/cm2 VCE=5V Ee=1mW /cm2 VCE=5V IC=1mA RL=1000Ω Min 400 --30 Typ --940 --Max 1100 ----Unit nm nm V
5 -----
-------
--0.4 100
V V nA
On State Collector Current Rise Time Fall Time
IC(ON) tr tf
0.3 -----
1.14 15 15
-----
mA
μS ---
Everlight Electronics Co., Ltd. Device No：DTT-012-083
http:\\https://www.wendangku.net/doc/146512844.html, Prepared date：07-20-2005
Rev 2
Page: 3 of 10
Prepared by：David Huang
元器件交易网https://www.wendangku.net/doc/146512844.html,
PT12-21C/TR8
Typical Electro-Optical Characteristics Curves
Fig.1Collector Power Dissipation vs. Ambient Temperature Fig.2 Spectral Sensitivity
100 80 60 40 20 0 -25 0 25 50 75 85 100
1.0 Ta=25 C 0.8 0.6 0.4 0.2 0 100 300 500 700 900 1100 1300
Fig.3 Relative Collector Current vs. Ambient Temperature
Fig.4 Collector Current vs. Irradiance
160 140 120 100 80 60 40 20 0 0 10 20 30 40 50 60 70
2
100 C 10
1
0.1
0.01 0.5
1
3
2
5
Everlight Electronics Co., Ltd. Device No：DTT-012-083
http:\\https://www.wendangku.net/doc/146512844.html, Prepared date：07-20-2005
Rev 2
Page: 4 of 10
Prepared by：David Huang
元器件交易网https://www.wendangku.net/doc/146512844.html,
PT12-21C/TR8
Typical Electro-Optical Characteristics Curves
Fig.5 Collector Dark Current vs. Ambient Temperature Fig.6 Collector Current vs. Collector-Emitter Voltage
10
14 12
10 10
10 8 6
10
4 2
10 0 25 50 75 100
0 0
1
2
3
4
Everlight Electronics Co., Ltd. Device No：DTT-012-083
http:\\https://www.wendangku.net/doc/146512844.html, Prepared date：07-20-2005
Rev 2
Page: 5 of 10
Prepared by：David Huang
元器件交易网https://www.wendangku.net/doc/146512844.html,
PT12-21C/TR8
Precautions For Use
1. Over-current-proof Customer must apply resistors for protection , otherwise slight voltage shift will cause big current change ( Burn out will happen ). 2. Storage 2.1 Do not open moisture proof bag before the products are ready to use. 2.2 Before opening the package, the LEDs should be kept at 30℃ or less and 90%RH or less. 2.3 The LEDs should be used within a year. 2.4 After opening the package, the LEDs should be kept at 30℃ or less and 70%RH or less. 2.5 The LEDs should be used within 168 hours (7 days) after opening the package. 2.6 If the moisture absorbent material (silica gel) has faded away or the LEDs have exceeded the storage time, baking treatment should be performed using the following conditions. Baking treatment : 60±5℃ for 24 hours. 3. Soldering Condition 3.1 Pb-free solder temperature profile
3.2 Reflow soldering should not be done more than two times. 3.3 When soldering, do not put stress on the LEDs during heating. 3.4 After soldering, do not warp the circuit board.
Everlight Electronics Co., Ltd. Device No：DTT-012-083
http:\\https://www.wendangku.net/doc/146512844.html, Prepared date：07-20-2005
Rev 2
Page: 6 of 10
Prepared by：David Huang
元器件交易网https://www.wendangku.net/doc/146512844.html,
PT12-21C/TR8
4.Soldering Iron Each terminal is to go to the tip of soldering iron temperature less than 280℃ for 3 seconds within once in less than the soldering iron capacity 25W. Leave two seconds and more intervals, and do soldering of each terminal. Be careful because the damage of the product is often started at the time of the hand solder. 5.Repairing Repair should not be done after the LEDs have been soldered. When repairing is unavoidable, a double-head soldering iron should be used (as below figure). It should be confirmed beforehand whether the characteristics of the LEDs will or will not be damaged by repairing.
Everlight Electronics Co., Ltd. Device No：DTT-012-083
http:\\https://www.wendangku.net/doc/146512844.html, Prepared date：07-20-2005
Rev 2
Page: 7 of 10
Prepared by：David Huang
元器件交易网https://www.wendangku.net/doc/146512844.html,
PT12-21C/TR8
Package Dimensions
Loaded Quantity Per Reel 2000PCS/Reel
Collector Emitter
Unit : mm
Everlight Electronics Co., Ltd. Device No：DTT-012-083
http:\\https://www.wendangku.net/doc/146512844.html, Prepared date：07-20-2005
Rev 2
Page: 8 of 10
Prepared by：David Huang
元器件交易网https://www.wendangku.net/doc/146512844.html,
PT12-21C/TR8
Reliability Test Item And Condition
The reliability of products shall be satisfied with items listed below. Confidence level：90% LTPD：10% NO. Item Test Conditions Test Hours/ Cycles 6Mins 50Cycles Sample Failure Sizes Judgement Criteria 22pcs 22pcs IC(ON)≦L×0.8 L：Lower 50Cycles 22pcs Specification Limit 0/1 Ac/Re
1 REFLOW Soldering TEMP.：240℃±5℃ 5secs 15mins 2 Temperature Cycle H : +100℃ L : -40℃ 3 Thermal Shock H :+100℃ L :-10℃ 4 High Temperature Storage 5 Low Temperature Storage 5mins 15mins 5mins 10secs 5mins
0/1 0/1
TEMP.：+100℃ TEMP.：-40℃
1000hrs 1000hrs 1000hrs 1000hrs
22pcs 22pcs 22pcs 22pcs
0/1 0/1 0/1 0/1
6 DC Operating Life VCE=5V 7 High Temperature/ 85℃ / 85% R.H High Humidity
Everlight Electronics Co., Ltd. Device No：DTT-012-083
http:\\https://www.wendangku.net/doc/146512844.html, Prepared date：07-20-2005
Rev 2
Page: 9 of 10
Prepared by：David Huang
元器件交易网https://www.wendangku.net/doc/146512844.html,
PT12-21C/TR8
Packing Quantity Specification
1.2000Pcs/1Volume，1Volume/1Bag 2.10Boxes/1Carton
Label Form Specification
CPN: Customer’s Production Number P/N : Production Number QTY: Packing Quantity CAT: Ranks HUE: Peak Wavelength REF: Reference LOT No: Lot Number MADE IN TAIWAN: Production Place
RoHS
PT12/21C/TR8
Notes
1. Above specification may be changed without notice. EVERLIGHT will reserve authority on material change for above specification. 2. When using this product, please observe the absolute maximum ratings and the instructions for using outlined in these specification sheets. EVERLIGHT assumes no responsibility for any damage resulting from use of the product which does not comply with the absolute maximum ratings and the instructions included in these specification sheets. 3. These specification sheets include materials protected under copyright of EVERLIGHT corporation. Please don’t reproduce or cause anyone to reproduce them without EVERLIGHT’s consent.
EVERLIGHT ELECTRONICS CO., LTD. Office: No 25, Lane 76, Sec 3, Chung Yang Rd, Tucheng, Taipei 236, Taiwan, R.O.C
Tel: 886-2-2267-2000, 2267-9936 Fax: 886-2267-6244, 2267-6189, 2267-6306 http:\\https://www.wendangku.net/doc/146512844.html,
Everlight Electronics Co., Ltd. Device No：DTT-012-083
http:\\https://www.wendangku.net/doc/146512844.html, Prepared date：07-20-2005
Rev 2
Page: 10 of 10
Prepared by：David Huang